What should I look for when choosing a repair shop?

• Ask for recommendations from friends, family, and other people you trust. Look for a repair shop before you need one to avoid being rushed into a last-minute decision.
• Shop around by phone and online for the best deal, and compare warranty policies on repairs.
• Ask to see current licenses if state or local law requires repair shops to be licensed or registered such as BAR. Also, your state Attorney General's office or local consumer protection agency may know whether there's a record of complaints about a particular repair shop. The Better Business Bureau may be helpful.
• Make sure the shop will honor your vehicle's warranty and does not void it.

1) How to Choose a Technician

Is one technician better than another?

• Look for shops that display various certifications — like an Automotive Service Excellence seal. Certification indicates that some or all of the technicians meet basic standards of knowledge and competence in specific technical areas. Make sure the certifications are current, but remember that certification alone is no guarantee of good or honest work.
• Ask if the technician or shop has experience working on the same make or model vehicle as yours.

2) Repair Charges: Unlocking the Mystery

Before you arrange to have any work performed, ask how the shop prices its work. Some shops charge a flat rate for labor on auto repairs. This published rate is based on an independent or manufacturer's estimate of the time required to complete repairs. Others charge on the basis of the actual time the technician worked on the repair.

If you need expensive or complicated repairs, or if you have questions about recommended work, consider getting a second opinion.

Find out if there will be a diagnostic charge if you decide to have the work performed elsewhere. Many repair shops charge for diagnostic time.

Shops that do only diagnostic work and do not sell parts or repairs may be able to give you an objective opinion about which repairs are necessary.

If you decide to get the work done, ask for a written estimate.

What should a written estimate include?

• It should identify the condition to be repaired, the parts needed, and the anticipated labor charge. Make sure you get a signed copy.
• It should state that the shop will contact you for approval before they do any work exceeding a specified amount of time or money. State law may require this.

What should I know about the parts to be repaired or replaced?

Types of Invoiced Parts:

• New — These parts generally are made to original manufacturer's specifications, either by the vehicle manufacturer or an independent company. Your state may require repair shops to tell you if non-original equipment will be used in the repair. Prices and quality of these parts vary.
• Remanufactured, rebuilt and reconditioned — These terms generally mean the same thing: parts have been restored to a sound working condition. Many manufacturers offer a warranty covering replacement parts, but not the labor to install them.
• Salvage — These are used parts taken from another vehicle without alteration. Salvage parts may be the only source for certain items, though their reliability is seldom guaranteed.

What do I need after the work is done?

Get a completed repair order describing the work to be completed. It should list each repair, parts supplied, the cost of each part, labor charges, and the vehicle's odometer reading when you brought the vehicle in as well as when the repair order was completed. Ask for all replaced parts. State law may require this.

4) Preventive Maintenance

What are the consequences of postponing maintenance?

Many parts on your vehicle are interrelated. Ignoring maintenance can lead to trouble: specific parts — or an entire system — can fail. Neglecting even simple routine maintenance, like changing the oil or checking the coolant, can lead to poor fuel economy, unreliability, or costly breakdowns. It also may invalidate your warranty.

What maintenance guidelines should I follow to avoid costly repairs?

Follow the manufacturer's maintenance schedule in your owner's manual for your type of driving. Some repair shops create their own maintenance schedules, which call for more frequent servicing than the manufacturer's recommendations. Compare shop maintenance schedules with those recommended in your owner's manual. Ask the repair shop to explain — and make sure you understand — why it recommends service beyond the recommended schedule.

5) Protecting Your Auto Repair Investment

What warranties and service contracts apply to vehicle repairs?

Warranties

There is no "standard warranty" on repairs. Make sure you understand what is covered under your warranty and get it in writing. Warranties may be subject to limitations, including time, mileage, deductibles, businesses authorized to perform warranty work or special procedures required to obtain reimbursement.

Check with your state Attorney General or local consumer protection agency or BAR for information about your warranty rights.

How do I resolve a dispute regarding billing, quality of repairs or warranties?

• Document all transactions as well as your experiences with dates, times, expenses, and the names of people you dealt with.
• Talk to the shop manager or owner first. If that doesn't work, contact your Attorney General or local consumer protection agency or BAR for help. These offices may have information on alternative dispute resolution programs in your community. Another option is to file a claim in small claims court. You don't need an attorney to do this.

6) Heading Off Problems

The more you know about your vehicle, the more likely you'll be able to head off repair problems. You can detect many common vehicle problems by using your senses: eyeballing the area around your vehicle, listening for strange noises, sensing a difference in the way your vehicle handles, or even noticing unusual odors.

7) Looks Like Trouble

Small stains or an occasional drop of fluid under your vehicle may not mean much. But wet spots deserve attention; check puddles immediately.

You can identify fluids by their color and consistency:

• Yellowish green, pastel blue or florescent orange colors indicate an overheated engine or an antifreeze leak caused by a bad hose, water pump or leaking radiator.
• A dark brown or black oily fluid means the engine is leaking oil. A bad seal or gasket could cause the leak.
• A red oily spot indicates a transmission or power-steering fluid leak.
• A puddle of clear water usually is no problem. It may be normal condensation from your vehicle's air conditioner.

8) Smells Like Trouble

Some problems are under your nose. You can detect them by their odor:

• The smell of burned toast — a light, sharp odor — often signals an electrical short and burning insulation. To be safe, try not to drive the vehicle until the problem is diagnosed.
• The smell of rotten eggs — a continuous burning-h smell — usually indicates a problem in the catalytic converter or other emission control devices. Don't delay diagnosis and repair.
• A thick acrid odor usually means burning oil. Look for sign of a leak.
• The smell of gasoline vapors after a failed start may mean you have flooded the engine. Wait a few minutes before trying again. If the odor persists, chances are there's a leak in the fuel system — a potentially dangerous problem that needs immediate attention.
• Burning resin or an acrid chemical odor may signal overheated brakes or clutch. Check the parking brake. Stop. Allow the brakes to cool after repeated hard braking on mountain roads. Light smoke coming from a wheel indicates a stuck brake. The vehicle should be towed for repair.
• A sweet, steamy odor indicates a coolant leak. If the temperature gauge or warning light does not indicate overheating, drive carefully to the nearest service station, keeping an eye on your gauges. If the odor is accompanied by a hot, metallic scent and steam from under the hood, your engine has overheated. Pull over immediately. Continued driving could cause severe engine damage. The vehicle should be towed for repair.

9) Sounds Like Trouble

Squeaks, squeals, rattles, rumbles, and other sounds provide valuable clues about problems and maintenance needs. Here are some common noises and what they mean:

Squeal — A shrill, sharp noise, usually related to engine speed:

• Loose or worn power steering, fan or air conditioning belt.

Click — A slight sharp noise, related to either engine speed or vehicle speed:

• Loose wheel cover.
• Loose or bent fan blade.
• Stuck valve lifter or low engine oil.

Screech — A high-pitched, piercing metallic sound; usually occurs while the vehicle is in motion:

• Caused by brake wear indicators to let you know it's time for maintenance.

Rumble — a low-pitched rhythmic sound.

• Defective exhaust pipe, converter or muffler.
• Worn universal joint or other drive-line component.

Ping — A high-pitched metallic tapping sound, related to engine speed:

• Usually caused by using gas with a lower octane rating than recommended. Check your owner's manual for the proper octane rating. If the problem persists, engine ignition timing could be at fault.

Heavy Knock — A rhythmic pounding sound:

• Worn crankshaft or connecting rod bearings.
• Loose transmission torque converter.

Clunk — A random thumping sound:

Loose shock absorber or other suspension component.

Loose exhaust pipe or muffler.

10) Feels Like Trouble

Difficult handling, a rough ride, vibration and poor performance are symptoms you can feel. They almost always indicate a problem.

Steering

• Misaligned front wheels and/or worn steering components, like the idler or ball joint, can cause wandering or difficulty steering in a straight line.
• Pulling — the vehicle's tendency to steer to the left or right — can be caused by something as routine as under-inflated tires, or as serious as a damaged or misaligned front end.

Ride and Handling

• Worn shock absorbers or other suspension components — or improper tire inflation — can contribute to poor cornering.
• While there is no hard and fast rule about when to replace shock absorbers or struts, try this test: bounce the vehicle up and down hard at each wheel and then let go. See how many times the vehicle bounces. Weak shocks will allow the vehicle to bounce twice or more.
• Springs do not normally wear out and do not need replacement unless one corner of the vehicle is lower than the others. Overloading your vehicle can damage the springs.
• Balance tires properly. An unbalanced or improperly balanced tire causes a vehicle to vibrate and may wear steering and suspension components prematurely.

Brakes

Brake problems have several symptoms. Schedule diagnosis and repair if:

• The vehicle pulls to one side when the brakes are applied.
• The brake pedal sinks to the floor when pressure is maintained.
• You hear or feel scraping or grinding during braking.
• The "brake" light on the instrument panel is lit.

Engine

The following symptoms indicate engine trouble. Get a diagnosis and schedule the repair.

• Difficulty starting the engine.
• The "check engine" light on the instrument panel is lit.
• Rough idling or stalling.
• Poor acceleration.
• Poor fuel economy.
• Excessive oil use (more than one quart between changes).
• Engine continues running after the key is removed.

Transmission

Poor transmission performance may come from actual component failure or a simple disconnected hose or plugged filter. Make sure the technician checks the simple items first; transmission repairs normally are expensive. Some of the most common symptoms of transmission problems are:

• Abrupt or hard shifts between gears.
• Delayed or no response when shifting from neutral to drive or reverse.
• Failure to shift during normal acceleration.
• Slippage during acceleration. The engine speeds up, but the vehicle does not respond.

11) Trouble Shooting

Car trouble doesn't always mean major repairs. Here are some common causes of trouble and techniques to help you and your technician find and fix problems:

• Alternator — Loose wiring can make your alternator appear defective. Your technician should check for loose connections and perform an output test before replacing the alternator.
• Battery — Corroded or loose battery terminals can make the battery appear dead or defective. Your technician should clean the terminals and test battery function before replacing the battery.
• Starter — What appears to be a defective starter actually may be a dead battery or poor connection. Ask your technician to check all connections and test the battery before repairing the starter.
• Muffler — a loud rumbling noise under your vehicle indicates a need for a new muffler or exhaust pipe.
• Tune-up — The old-fashioned "tune-up" may not be relevant to your vehicle. Fewer parts, other than belts, spark plugs, hoses and filters, need to be replaced on newer vehicles. Follow the recommendations in your owner's manual.